Rav4 EV Data Range Test 7-15-06
       
Date: 15-Jul 15-Jul Total
Start Time: 4:49 9:20   Other Data
End Time: 9:20 9:39   Start SOC 0% End
    Temps

Range Test:

Started at about 4:30am and drove up to the 210, over to the 15 and down
to Baseline. Then decided on a route on Baseline from just west of Haven to
just east of Sierra. Distance was about 15 miles round trip. Route was very
level with a slight elevation increase from Haven to Sierra. Minimal lights
along the way. Drove between 40-45 MPH all the way when not needing to stop
for a light or traffic. Continued on this loop until hitting 0.0 SOC.

Ran with fan on low the whole trip and with headlights for the first 1.5 hours.
Temps started to go up quickly once the sun came up. The battery fan came on low
at about 50% SOC and T1 of 94¡ and then switched to high shortly thereafter and
ran continuously through the end of the test.

At 0.8 SOC the turtle came on for the first time. Had to slow down to
continue. Shortly after 0.0 SOC the turtle came on again and beeped and the
car died. The MIN battery was at 7.0 volts. The MAX and AVG were over 10 at
all times.

I was about 3 miles from home and had to creep slowly at under 10 MPH to
get home and keep the MIN above 8.0 on acceleration. The turtle came on and
the car died about 3 or 4 times during that time.

Battery Voltages stayed within 0.1 volt until SOC was under 15%. Gradually increased
to up to 0.8 volts when stopped (larger when accelerating and under 1.0% SOC).
Start Miles (trip): 0.0 136.9   TA 79.4 97.0 97.7
End Miles (trip): 136.9 140.6   T1 88.6 103.2 103.1
    T2 86.2 101.6 100.9
Start Energy (whrs): 0 24214   T3 84.3 100.3 99.5
End Energy (whrs): 24214 24937  
    Start SOC 0% End
Start SOC(%): 100.0% 0.0%   Battery Voltages
End SOC (%): 0.0% 0.0%   Min 14.4 10.1 9.8
    Max 14.5 10.8 10.6
Total Time (min): 271.0 19.0 290.0 Avg 14.5 10.5 10.3
Total Miles: 136.9 3.7 140.6 Calc 348.0 252.0 247.2
Energy (whrs): 24214 723 24937 Actual 246.1
Destination: 100 to 0% After 0% Total Spread 0.1 0.7 0.8
Average MPH: 30.3 11.7 29.1
Charge Used (%): 100.0% 0.0% 100.0% SOC% Miles Calc Range
whrs/mile: 176.9 195.4 177.4 Warnings
Miles/Charge: 136.9 #DIV/0! 140.6 Light 23.1% 108.8 141.5
Pack Capacity (kWh): 24.2 #DIV/0! 24.9 Blink 17.2% 116.2 140.3
    Full Trip   Turtle 0.8% 135.9 137.0
Total Miles:   140.6 Miles/Charge
Average MPH:   29.1 140.6 SOC% Miles Calc Range
Charge Used (%):   100.0%   Checks
whrs/mile:   177.4   Quarter 75.0% 35.6 142.4
Miles/Charge:   140.6   One-Third 66.6% 47.3 141.6
Pack Capacity (kWh):   24.9   Half 50.0% 71.1 142.2
Two-Thirds 33.3% 94.6 141.8
100 Miles 29.9% 100.0 142.7
Start Regen 0 8052 8052 Three-Qtr 25.0% 106.1 141.5
End Regen 8052 8157 16209 Average 142.0
Total 8052 105 8157
   
Start Energy 0 32268 32268 Start Miles 89655
End Energy 32268 33096 65364 End Miles 89795
Total 32268 828 33096
   
% Regen 25.0% 12.7% 24.6%